INTRODUCTION
Periprosthetic Joint Infection (PJI) is a devastating and costly complication after Total Joint Arthroplasty (TJA) (Morcos et al. 2021; Parisi, Konopka, and Bedair 2017; Parvizi et al. 2010; Walter et al. 2021). A large body of literature has been published regarding the optimal methods for preventing infection by optimizing patient care prior to surgery (Antonelli and Chen 2019; Batty and Lanting 2020; Chan et al. 2020; Shahi and Parvizi 2015). However, one method of infection prophylaxis that has recently become a larger clinical focus is post-operative wound management (Chowdhry and Chen 2015; Sharma et al. 2017). This is especially important in TJA, where patients are mobile immediately after surgery, placing significant stress on the surgical wound. Optimal wound management is critical, since wound breakdown, if left untreated, could lead to PJI (Chowdhry and Chen 2015).
Historically, simple gauze and tape dressings were considered the standard of care post-operatively, but there have been recent advances in dressing technology that offer a theoretical advantage in wound management and infection prevention (Sharma et al. 2017). Unlike classic gauze-based dressings, which only offer a passive protective barrier, new dressing technologies can actively maintain an optimal moist wound environment for up to a week after surgery, sometimes with additional antimicrobial properties (Chen et al. 2018; Herndon et al. 2020). There is a growing body of research that investigates the clinical effectiveness of these new dressings in comparison to traditional wound care methods. However, the economic aspects of these dressings must also be considered prior to their implementation.
Few prior studies have examined the cost effectiveness of individual types of surgical dressings after lower extremity arthroplasty. Toppo et al. found that silver impregnated occlusive dressings were a cost-effective measure for preventing infection after TJA, while Nherera et al. found that single-use negative pressure wound therapy can be a cost-saving intervention to prevent wound complications after primary total joint replacements (Nherera, Trueman, and Karlakki 2017; Toppo et al. 2020). However, these studies only examined a single dressing type and did not examine a range of available products. The purpose of our study was to conduct a break-even analysis comparing a range of advanced technology dressings that are widely used in TJA. The dressings analyzed included: 1) Xeroform with gauze, a simple gauze dressing impregnated with petrolatum and the antimicrobial agent bismuth; 2) Mepilex Border, a bordered foam dressing; 3) Aquacel Ag, a hydrofiber dressing impregnated with ionic silver; and 4) Dermabond Prineo, a polyester mesh and liquid adhesive wound closure system. We used a simple economic model to determine the required reduction in infection for each of these wound care technologies to make them cost-effective for routine use in TJA patients. We present the following article in accordance with the CHEERS reporting checklist.
METHODS
As a model for cost-effectiveness, we utilized a break-even formula originally described by Hatch et al (Hatch et al. 2017). for our analysis of wound dressings (Figure 1). This formula solves for a break-even infection rate, which is the infection rate that would need to be achieved with the use of a particular intervention (e.g., a particular dressing) to neutralize cost of using that intervention compared to the cost of treating an infection. Three variables are factored in the break-even equation: initial infection rate of the procedure, the total cost of treating an infection resulting from the procedure, and the total cost of the intervention meant to ameliorate infection risk. Calculating the difference between initial infection rate and the break-even infection rate provides the absolute risk reduction (ARR), which is the percent difference that the use of a particular intervention must yield for its prophylactic use to be economically justified.
The values for each variable were collected from the contemporary literature. No experiment or intervention was implemented and no patient data was used in this study; this study is therefore exempt from Institutional Review Board review. Regarding initial infection rates following TJA, rates range from high national incidences of 2.18% for both TKA and THA to lower incidences of 1.10% and 1.63% for TKA and THA, respectively (Kurtz et al. 2012; Ong et al. 2009; Pulido et al. 2008). For our calculations, the lower incidence rates were used as baseline infection rates to create a more conservative analysis. The cost of treating infection was obtained from literature on the cost of double-stage revision arthroplasty. Cost burden due to PJI has been found to be nearly twice as high as those without PJI, with costs reaching as high as $80,000 in the United States (Leta et al. 2021). These costs represent inpatient fees, excluding professional and non-covered charges. For our calculations we used the greater of these costs for both TKA and THA given that they represent more recent estimates.
Regarding the wound dressings, four distinct dressings were analyzed. These ranged from simple dressings that may be constructed from materials readily available in most operating rooms to highly specialized dressings. We denoted a single-use Xeroform with gauze (Xeroform+gauze) as the standard dressing, which costs approximately $3.00 (Grosso et al. 2017). When Xeroform+gauze is utilized at our institution, a dressing change occurs on each post-operative day until discharge. Accounting for this, we also included Xeroform+gauze with 2 or 3 dressing changes, costing a total of $9.00 and $12.00, respectively. At our institution, the most readily available prefabricated dressing that is utilized for total joint arthroplasty is the Mepilex Border dressing, which cost $29.00 per dressing (Holte et al. 2017). Silver-impregnated Aquacel Ag dressings were also analyzed, with a cost of $40.00 per dressing (Grosso et al. 2017). Finally, a polyester mesh dressing, the Dermabond Prineo, was analyzed at a cost of $79.00 per dressing (Herndon et al. 2020).
Rates of infection and cost of treating infection are subject to variations based on a multitude of factors that are challenging to capture within a cost-effectiveness model. Therefore, each of these variables were manipulated along a range of theoretical costs to determine how variations might impact the ARR. For example, we performed our calculations using initial infection rates that ranged of 0.50-2.5%. Furthermore, we varied the cost of treating infection from $20,000 to $40,000. These ranges account for differences in infection rates and costs of treatment between institutions and practice-settings, and we conducted break-even analyses across these ranges to determine if the cost-effectiveness of each dressing type is impacted by variations in infection rates and costs of infection treatment.
RESULTS
At a cost of $3.00, Xeroform+gauze is cost-effective if the initial infection rates for THA and TKA (1.63% and 1.10%, respectively) have an ARR of 0.01% each (Table 1). If Xeroform+gauze is changed 3 or 4 times for a total cost of $9.00 and $12.00, respectively, cost-effectiveness would be achieved with an ARR of 0.03% and 0.04% at each respective price point for THA, and with an ARR of 0.04% and 0.05% for TKA. Furthermore, at a cost of $29.00, the Mepilex Border dressing would require an ARR of 0.09% for THA and 0.11% for TKA. The Aquacel Ag dressing, with a cost of $40.00, would require an ARR of 0.13% and 0.16% for THA and TKA, respectively. Finally, for a Dermabond Prineo dressing at $79.00, the ARR would be 0.25% for THA and 0.31% for TKA.
Varying the initial infection rate for both THA and TKA from 0.5% to 2.5% did not impact the ARR required to break-even on cost regardless of the dressing type (Table 2). For example, at an initial infection rate of 0.50%, the Dermabond Prineo requires an ARR of 0.25% to break-even for THA and TKA, which is the same ARR calculated with an initial infection rate of 1.0%, 1.5%, 2.0% and 2.5%.
Changing the cost of treating infection resulted in the greatest change in the ARR required to break-even on the cost of implementing a particular wound dressing (Table 3). For example, at a treatment cost of $20,000 for a periprosthetic hip infection, the Dermabond Prineo requires an ARR of 0.40% to break-even on cost. However, when cost of treating infection increases to $40,000 for a periprosthetic hip infection, the Dermabond Prineo requires a smaller ARR of 0.20% to break-even. This trend is maintained for the other dressing types, as well as for periprosthetic knee infections.
DISCUSSION
PJI is a devastating complication of TJA the presents substantial costs to the patient and surgeon. Toppo et al. found that silver impregnated occlusive dressings were a cost-effective measure for preventing infection after TJA, while Nherera et al. found that single-use negative pressure wound therapy can be a cost-saving intervention to prevent wound complications after primary total joint replacements (Nherera, Trueman, and Karlakki 2017; Toppo et al. 2020). However, these studies only examined a single dressing type and did not examine a range of available products. Our study presents that absolute risk reductions that would be necessary for post-operative wound dressings that cost between $12 and $80 (USD) to be cost-effective in situation where the baseline post-operative infection rate in 0.5% to 2.5% and the cost of treating the infection can reach up to $80,000 (USD). Depending upon these inputs, post-operative surgical dressings are cost-effective if they reduced that relative risk of infection by 0.03 – 0.40% (Tables 2 and 3).
This study is a theoretical exercise and should not be interpreted as a report of the clinical effectiveness of any specific post-operative dressing. This study is not an experimental study and does not describe the result of any particular intervention, rather this study presents a cost-effectiveness model that computes the absolute risk reduction that should be observed in an experimental study in order for a given dressing type to be considered cost-effective. Kuo et al. found that antimicrobial dressings had the lowest odds ratio for the incidence of infections, followed by hydrofiber/hydrocolloid, foam, impregnated gauze, and film dressings (Kuo et al. 2021). Nevertheless, a clinical or experimental study would be necessary to determine if an intervention related to post-operative surgical dressing type is truly cost-effective in practice.
Furthermore, the design of this study assumes that the value of post-operative dressings is related only to their ability to prevent post-operative infection. There may be other characteristics of different dressing types that present advantages to the surgeon and patient – such as aesthetics, resistance to bathing and showering, and a lesser need for dressing changes – and these may be properties that surgeons and patients value, but this study does not account for these differences because in our opinion the primary function of a post-operative wound dressing is as physical barrier to prevent post-operative infection.
Similarly, the findings of this study are generalized to the average patient, but there may be clinical scenarios in which alternative dressings or wound management strategies – such as incisional wound vacs – may be preferable. This may be the cases in revision surgery or in patients with specific allergies, complex medical comorbidities, or those who are otherwise at increased risk for wound complications. The value and cost-effectiveness of alternative wound management strategies in specific patient populations and clinical scenarios may be a topic for further study.
In addition, the findings of this model are dependent upon the input values for dressing cost, infection rates, and the costs of treating infection that we found in the literature available. It is possible that in the future the baseline rate of infection and the monetary costs of treating infection could change, and this could impact the study findings. Septic revision arthroplasty is complex, and the decision-making process is dynamic and individualized. There are many costs and considerations that can vary substantially over time and in different scenarios, and for these reasons a decision-tree analysis or time-dependent Markov model could be used to more accurately reflect the complexity of the decision-making in septic revision arthroplasty, however we present a break-even analysis because it is a statistical method that most decision-makers can fully understand and could easily apply to their own practices. Future studies could investigate how the nonmonetary elements related to treating infection, including the loss of physiology, psychology, and work time, further contributes to the overwhelming costs and consequences of treating a PJI.
It is also possible that the costs of specific dressings could change or that institutions or practices could adjust the unit cost of dressing types via collective bargaining or group-purchasing agreements. It is for these reasons that we computed break-even points for a range of dressing costs, baseline infection rates, and costs of treating infection. Surgeons interpreting our study findings may compare their local or institutional costs and rates to those presented in tables 2 and 3 to find an approximate break-even point for the costs and rates observed in any given practice. Using the equation in figure 1, surgeons considering a change in dressing type could determine the precise break-even point given the costs are rates observed in their practices. This could be a basis for a future practical study.
CONCLUSION
This break-even analysis investigates the cost-effectiveness of various dressings used in TJA, ranging from standard dressings that are available with materials found in most operating rooms to highly specialized wound dressings. Standard dressings, such as Xeroform and gauze, are predictably cost-effective. However, cost-effectiveness diminishes greatly with the increasing costs of specialized dressings, such as the Aquacel Ag and Dermabond Prineo. Notably, the break-even analysis utilized in our study can be applied to any joint replacement surgeon’s practice using their outcome data and product costs to determine which wound dressings is cost-effective for their practice.